外墙湿贴石材施工工艺

外墙湿贴石材 施工 文明施工目标施工进度表下载283施工进度表下载施工现场晴雨表下载施工日志模板免费下载 工艺 钢结构制作工艺流程车尿素生产工艺流程自动玻璃钢生产工艺2工艺纪律检查制度q345焊接工艺规程 作者: 来源:互联网 浏览次数:718 [2012-01-07 09:28:31] 分享| 施工工艺 工地收货 ?清理结构表面?结构上弹出垂直线?大角挂两竖直钢丝?石料打孔?背面刷胶?贴柔性加强 材料 关于××同志的政审材料调查表环保先进个人材料国家普通话测试材料农民专业合作社注销四查四问剖析材料 、挂水平位置线?支底层板托架?放置底层板定位?调节与临时固定?灌M20水泥?设排水管?结构钻孔并插固定螺栓?镶不锈钢固定件?用胶粘剂灌下层墙板上孔?插入连接钢针?将胶粘剂灌入上层墙板的下孔内、临时固定上层墙板?钻孔插入膨胀螺栓?镶不锈钢固定件?镶顶层墙板?临时固定上层墙板B、施工方法 1石材准备:用比色法对石材的颜色进行挑选分类，安装在同一面的石材颜色应一致，按 设计 领导形象设计圆作业设计ao工艺污水处理厂设计附属工程施工组织设计清扫机器人结构设计 图纸及分块顺序将石材编号。 2基层准备:清理预做饰面石材的结构表面，同时进行结构套方，找规矩，弹出垂直线和水平线。并根据设计图纸和实际需要弹出安装石材的位置线和分块线。 3挂线:根据设计图纸要求，石材安装前要事先用经纬仪打击大角两个面的竖向控制线，最好弹在离大角20cm的位置上，以便随时检查垂直挂线的准确线，保证顺利安装，并在控制线的上下作出标记。 4支底层饰面板托架，把预先安排好的支托按上平线支在将要安装的底层石板上面。支托要支承牢固，相互之间要连接好，也可和架子接在一起，支架安好后，顺支托方向钉铺通长的50mm厚木板，木板上口要在同一个水平面上，以保证石材上下面处在同一水平面上。 5上连接铁件:用设计规定的不锈钢螺栓固定角钢和平钢板。调整平钢板的位置，使平钢板的小孔正好与石板的插入孔对上，固定平钢板，用扳子拧紧。 6底层石板安装:把侧面的连接铁件安好，便可把底层面板靠角上的一块就位。 7调整固定:面板暂固定后，调整水平度，如板面上口不平，可在板底的一端下口的连接平钢板上垫一相应的双股铜丝垫。调整垂直度，并调整面板上口的不锈钢连接件的距墙空隙，直至面板垂直。 8顶部面板安装:顶部最后一层面板除了解按一般石板安装要求外，安装调整好，在结构与石板的缝隙里吊一通长的20mm厚木条，木条上平为石板上口下去250mm，吊点可设在连接铁件上。可彩铝丝吊木条，木条吊好后，即在石板与墙面之间的空隙里放填充物，且填塞严实，防止灌浆时漏浆。 9、清理大理石、花岗石表面:把大理石、花岗石表面的防污条掀掉，用棉丝把石板擦净。 C、成品保护 1要及时清擦，净残留在门窗框、玻璃和金属、饰面板上污物。 2认真贯彻合理施工顺序，少数工种的活应做在前面、防止损坏、污染外挂石材饰面板。 3拆改架子和上料时，严禁碰撞干挂石材饰面板。 4外饰面完活后，易破损部分的棱角处要钉护角保护，其他工种操作时不得划伤面漆和碰坏石材。 other related procedures. The Bank strictly enforced lending principles, carried out by the Centre for lending or lending review loan review function. Lenders loan review staff should be thoroughly examined whether the criteria are met, the approval conditions implementation, security is normal and borrower credit operations, such as whether there was a major early warning information. Meet the lending criteria, according 5完工的外挂石材应设专人看管，遇有危害成品的行为，应立即制止，并严肃处理。 D、注意的质量问题 1外饰石板面层颜色不一，主要是石材质量较差，施工时没有进行试拼和认真的挑选。线条不直，缝格不匀，不直，主要是施工前没有认真按图纸尺寸，核对结构施工的实际尺寸，以及分段分块，不弹线不细，拉线不直和吊线校正不勤等原因造成。 2打胶嵌缝不细，操作人员应认真施工，检查人员应细致验收。 3墙面脏、斜视有胶痕，一是操作工艺造成，二是操作人员造成，要加强成品保护，在竣工前进行认真清理。 E、质量标准 (一)主控项目 1石材墙面工程所用材料的品种、规格、性能和等级，应符合设计要求及国家现行产品标准和工程技术规范的规定。 2石材墙面的造型、立面分格、颜色、光泽、花纹和图案应符合要求。 3石材孔、槽的数量、深度、位置、尺寸应符合设计要求。 4墙角的连接节点应符合设计要求和技术标准的规定。 5石材表面和板缝的处理应符合设计要求。 (二)一般项目 1石材墙面表面应平整、洁净，无污染、缺损和裂痕。颜色和花纹应协调一致，无明显色差，无明显修痕。 2石材接缝应横平竖直、宽窄均匀;阴阳角石板压向应正确，板边合缝应顺直;凹凸线出墙厚度应一致，上下口应平直;石材面板上洞口、槽边应套割吻合，边缘应整齐。 other related procedures. The Bank strictly enforced lending principles, carried out by the Centre for lending or lending review loan review function. Lenders loan review staff should be thoroughly examined whether the criteria are met, the approval conditions implementation, security is normal and borrower credit operations, such as whether there was a major early warning information. Meet the lending criteria, according other related procedures. The Bank strictly enforced lending principles, carried out by the Centre for lending or lending review loan review function. Lenders loan review staff should be thoroughly examined whether the criteria are met, the approval conditions implementation, security is normal and borrower credit operations, such as whether there was a major early warning information. Meet the lending criteria, according other related procedures. The Bank strictly enforced lending principles, carried out by the Centre for lending or lending review loan review function. Lenders loan review staff should be thoroughly examined whether the criteria are met, the approval conditions implementation, security is normal and borrower credit operations, such as whether there was a major early warning information. Meet the lending criteria, according other related procedures. The Bank strictly enforced lending principles, carried out by the Centre for lending or lending review loan review function. Lenders loan review staff should be thoroughly examined whether the criteria are met, the approval conditions implementation, security is normal and borrower credit operations, such as whether there was a major early warning information. Meet the lending criteria, according other related procedures. The Bank strictly enforced lending principles, carried out by the Centre for lending or lending review loan review function. Lenders loan review staff should be thoroughly examined whether the criteria are met, the approval conditions implementation, security is normal and borrower credit operations, such as whether there was a major early warning information. Meet the lending criteria, according other related procedures. The Bank strictly enforced lending principles, carried out by the Centre for lending or lending review loan review function. Lenders loan review staff should be thoroughly examined whether the criteria are met, the approval conditions implementation, security is normal and borrower credit operations, such as whether there was a major early warning information. Meet the lending criteria, according other related procedures. The Bank strictly enforced lending principles, carried out by the Centre for lending or lending review loan review function. Lenders loan review staff should be thoroughly examined whether the criteria are met, the approval conditions implementation, security is normal and borrower credit operations, such as whether there was a major early warning information. Meet the lending criteria, according other related procedures. The Bank strictly enforced lending principles, carried out by the Centre for lending or lending review loan review function. Lenders loan review staff should be thoroughly examined whether the criteria are met, the approval conditions implementation, security is normal and borrower credit operations, such as whether there was a major early warning information. Meet the lending criteria, according other related procedures. The Bank strictly enforced lending principles, carried out by the Centre for lending or lending review loan review function. Lenders loan review staff should be thoroughly examined whether the criteria are met, the approval conditions implementation, security is normal and borrower credit operations, such as whether there was a major early warning information. Meet the lending criteria, according other related procedures. The Bank strictly enforced lending principles, carried out by the Centre for lending or lending review loan review function. Lenders loan review staff should be thoroughly examined whether the criteria are met, the approval conditions implementation, security is normal and borrower credit operations, such as whether there was a major early warning information. Meet the lending criteria, according other related procedures. The Bank strictly enforced lending principles, carried out by the Centre for lending or lending review loan review function. Lenders loan review staff should be thoroughly examined whether the criteria are met, the approval conditions implementation, security is normal and borrower credit operations, such as whether there was a major early warning information. Meet the lending criteria, according other related procedures. The Bank strictly enforced lending principles, carried out by the Centre for lending or lending review loan review function. Lenders loan review staff should be thoroughly examined whether the criteria are met, the approval conditions implementation, security is normal and borrower credit operations, such as whether there was a major early warning information. Meet the lending criteria, according other related procedures. The Bank strictly enforced lending principles, carried out by the Centre for lending or lending review loan review function. Lenders loan review staff should be thoroughly examined whether the criteria are met, the approval conditions implementation, security is normal and borrower credit operations, such as whether there was a major early warning information. Meet the lending criteria, according other related procedures. The Bank strictly enforced lending principles, carried out by the Centre for lending or lending review loan review function. Lenders loan review staff should be thoroughly examined whether the criteria are met, the approval conditions implementation, security is normal and borrower credit operations, such as whether there was a major early warning information. Meet the lending criteria, according