烟气脱硫设计计算表格V0.0

工况烟气量计算湿基烟气折算干基烟气量计算烟气温度（℃）标况烟气量（Nm3/h）工况烟气量（m3/h）烟气含水量湿基烟气量（m3/h）干基烟气量（m3/h）以下条件在计算方法中被简化150.0060000.0092967.035.061256682.001193093.89不包括吸收塔的热损失标况烟气量计算干基烟气折算湿基烟气量计算假设烟气带入的粉尘为零烟气温度（℃）工况烟气量（m3/h）标况烟气量（Nm3/h）烟气含水量干基烟气量（m3/h）湿基烟气量（m3/h）假设工艺水和石灰石不含杂质150.0092967.0059999.985.061193075.001256662.10假设原烟气和净烟气没有夹带物代入和带出系统假设原烟气和净烟气没有夹带物代入和带出系统假设没有除雾器冲洗水假设没有泵的密封水实际氧烟气量计算SO2浓度计算假设工艺系统是封闭的，没有环境物质的进入和流出烟气含氧量6%氧烟气量（m3/h）实际氧烟气量（m3/h）SO2浓度（PPm）SO2浓度(mg/Nm3）5.061256682.001335434.071761.005031.186%氧烟气量计算SO2排放浓度计算根据经验，当烟气中含氧量为6％以上时，在吸收塔喷淋区域的氧化率为50－60％。烟气含氧量实际烟气量（m3/h）6%氧烟气量（m3/h）脱硫效率SO2排放浓度（PPm）SO2排放浓度(mg/Nm3）采用氧枪式氧化分布技术，在浆池中氧化空气利用率ηo2=25－30％5.061193075.001122718.0195.0088.05251.56K根据浆液溶解盐的多少根据经验来确定，一般在2.0-3吸收塔出口烟气量G2（简化计算）G2＝(G1×（1－mw1）×(P2/(P2-Pw2))×（1－mw2）＋G3×（1－0.21/K）)×(P2/(P2-Pw2))氧化空气用量S=(G1×q1-G2×q2)×(1-0.6)/2/22.4参数参数值烟气量参数参数值需氧量吸收塔入口烟气量（G1）#DIV/0!G10.00入口烟气含湿率(mw1)q1所需空气流量Qreq Qreq=S×22.4/(0.21×0.3)烟气压力P2G2饱和烟气水蒸气分压(pw2)q20.00入口烟气含湿率(mw2)过量空气氧化率50.00实际空气用量Q吸收塔漏风烟气量（G3）溶解氧影响系数K2.500.00K根据脱硫量估算氧硫比4.00根据含量估算15062.55石灰石消耗量W1=100×qs×ηs废水排出量Y=（Gw*Cl水+Bg*Cl煤-G石膏含水CL石膏）/20g/L石灰石消耗量W1=100×qs×ηs参数值CaCO3消耗量kg参数参数值废水排出量入口SO2流量301872000.0000298.73工艺水用量Gw0.00脱硫效率95.0000考虑Ca/S比1.02工艺水含氯Cl水标况烟气量（Nm3/h）60000.0000304.70燃煤量BgSO2浓度(mg/Nm3）5031.2000需消耗的石灰石燃煤含氯Cl煤石灰石纯度0.9100334.84石膏带出水G石膏含水石膏带出水Cl石膏烟气蒸发水量计算烟气中夹带的水（安5%质量计算）参数参数值计算值入口烟气温度T1烟气平均比热参数参数值计算值出口烟气温度T20.0000出口烟气质量夹带水量入口烟气比热Cp1（kcal/kg.℃）氧化空气平均比热夹带水比例0.05000.00出口烟气比热Cp2（kcal/kg.℃）0.2461入口氧化空气温度T380.0000烟气温度差入口氧化空气温度T440.00000.0000制备石灰浆液需要的工艺水入口空气比热Cp1（kcal/kg.℃）0.2481空气温度差出口空气比热Cp2（kcal/kg.℃）0.244140.0000参数参数值计算值水的比热Cp水（kcal/kg.℃）1.0000烟气蒸发水量石灰浆液浓度0.3000需水量水的蒸发潜热r水（T1）584.74140.0000石灰石用量334.8374781.29水的蒸发潜热r水（T2）574.1301制备石灰浆液需要的浆液水烟气处理量Kg/h氧化空气用量Kg/h参数参数值计算值脱硫剂入口温度20.0000浆液水含固量0.0260需水量石膏浆液温度40.0000石灰石用量334.837498641.48工况烟气量计算烟气温度（℃）标况烟气量（Nm3/h）工况烟气量（m3/h）150.0060000.0092967.03输入值计算值标况烟气量计算锅炉数量1.00烟气温度（℃）工况烟气量（m3/h）标况烟气量（Nm3/h）脱硫塔计算 公式 小学单位换算公式大全免费下载公式下载行测公式大全下载excel公式下载逻辑回归公式下载 150.00180000.00116170.21设计参数单位数值耗水量计算塔高m18.00系统进口烟气温度（℃）标况烟气量（Nm3/h）系统出口烟气温度（℃）塔径m4.00150.00180000.0065.0085%生石灰价格元/吨300.00脱硫塔蒸发水量（Kg/h）除雾器冲洗水量（Kg/h）钠碱含水量（Kg/h）烧碱价格元/吨3000.004500.003391.205.76脱硫效率%93.00二氧化硫含量计算年运行时间h8000.00耗煤量（t/h）标况烟气量（Nm3/h）燃煤含硫率（%）脱硫塔截面积m212.565.0050000.001.00烟气流速m/s3.98二氧化硫浓度（mg/Nm3）二氧化硫总量（Kg/h）二氧化硫脱除量（Kg/h）年脱出SO2总量t632.401700.0085.0079.05纯生石灰的量t/年581.02物料计算(小时耗量)烧碱的量t/年19.86排放浓度（mg/Nm3）脱硫效率（%）纯生石灰的量（Kg/h）85%生石灰的量t/年683.55400.0076.4772.63生石灰费用万元20.51需要烧碱的量（Kg）石膏产生量（Kg/h）氧化空气用量（m3/h）烧碱费用万元5.9698.81212.6479.05石膏结晶水（Kg/h）脱硫渣含水（Kg/h）烧碱耗量（Kg/h）44.5121.262.47反应池中的钠、钙、硫平衡进反应池的Na2SO3进反应池的Ca(OH)2出反应池的CaSO3155.6391.40148.22出反应池的Na(OH)98.81温度饱和蒸气压温度饱和蒸气压温度饱和蒸气压温度/℃t/℃/(千Pa)t/℃/(千Pa)t/℃/(千Pa)15℃00.61129125232.012503973.6该温度下的饱和蒸汽压（ 表 关于同志近三年现实表现材料材料类招标技术评分表图表与交易pdf视力表打印pdf用图表说话 pdf 中查）/千pa10.65716126239.242514041.220.70605127246.662524109.6水蒸气的压力/千pa30.75813128254.252534178.91.7056千pa1.023千pa40.81359129262.042544249.1水蒸气占环境空气体积比/%50.8726130270.022554320.2相对湿度/%1.010%60.93537131278.22564392.260%每m3环境空气中含有的水蒸气的摩尔数/（mol/m3环境空气）71.0021132286.572574465.181.073133295.152584539环境压强/千pa0.004mol/m3空气91.1482134303.932594613.7该温度下的绝对湿度/（g/m3）即空气含湿量/（g/m3）101.2281135312.932604689.4101.32千pa111.3129136322.142614766.1121.4027137331.572624843.70.0777g/m3空气131.4979138341.222634922.3141.5988139351.092645001.8151.7056140361.192655082.3ρ=PM/(RT)161.8185141371.532665163.87.69304787110.0777171.938142382.112675246.3182.0644143392.922685329.8192.1978144403.982695414.3ΔH=463.677(617.426-T)0.28786----远离临界点'v$L,Y:I!e#}1Q202.3388145415.292705499.9ΔH=308.741(647.3-T)0.35389----全程0O0I&v+u1Y1z  y#p212.4877146426.852715586.4式中:T——沸点，K222.6447147438.672725674ΔH——水的蒸发潜热,kJ/kg7m3p&p,f,P232.8104148450.752735762.7这是我给维维软件当初建立的水蒸发潜热ΔH数学模型，你见过这么简单的公式吗？但他却是简洁而准确的。翻翻你手头的手册，看看有没有这个公式，比如《化工原理》？242.985149463.12745852.4这也是Them(换热器大师)、XHeater、VHeater使用的模型，维维软件开发了好多更精确的热力学、传热模型，用在自己的软件中。253.169150475.722755943.1R现在把它首次公开在海川论坛，供海友使用。263.3629151488.612766035273.567152501.782776127.9283.7818153515.232786221.9294.0078154528.962796317.2304.2455155542.992806413.2314.4953156557.322816510.5324.7578157571.942826608.9335.0335158586.872836708.5345.3229159602.112846809.2355.6267160617.662856911.1365.9453161633.532867014.1376.2795162649.732877118.3386.6298163666.252887223.7396.9969164683.12897330.2407.3814165700.292907438417.784166717.832917547428.2054167735.72927657.2438.6463168753.942937768.6449.1075169772.522947881.3459.5898170791.472957995.24610.094171810.782968110.34710.62172830.472978226.84811.171173850.532988344.54911.745174870.982998463.55012.344175891.83008583.85112.97176913.033018705.45213.623177934.643028828.35314.303178956.663038952.65415.012179979.093049078.25515.7521801001.93059205.15616.5221811025.23069333.45717.3241821048.93079463.15818.15918310733089594.25919.0281841097.53099726.76019.9321851122.53109860.56120.8731861147.93119995.86221.8511871173.8312101336322.8681881200.1313102716423.9251891226.1314104106525.0221901254.2315105516626.1631911281.9316106946727.3471921310.1317108386828.5761931338.8318109846929.8521941368319111317031.1761951397.6320112797132.5491961427.8321114297233.9721971458.5322115817335.4481981489.7323117347436.9781991521.4324118897538.5632001553.6325120467640.2052011568.4326122047741.9052021619.7327123647843.6652031653.6328125257945.4872041688329126888047.3732051722.9330128528149.3242061758.4331130198251.3422071794.5332131878353.4282081831.1333133578455.5852091868.4334135288557.8152101906.2335137018660.1192111944.6336138768762.4992121983.6337140538864.9582132023.2338142328967.4962142063.4339144129070.1172152104.2340145949172.8232162145.7341147789275.6142172187.8342149649378.4942182230.5343151529481.4652192273.8344153429584.5292202317.8345155339687.6882212362.5346157279790.9452222407.8347159229894.3012232453.8348161209997.7592242500.534916320100101.322252547.935016521101104.992262595.935116825102108.772272644.635216932103112.662282694.135317138104116.672292744.235417348105120.792302795.135517561106125.032312846.735617775107129.39232289935717992108133.882332952.135818211109138.52343005.935918432110143.242353060.436018655111148.122363115.736118881112153.132373171.836219110113158.292383288.636319340114163.582393286.336419574115169.022403344.736519809116174.612413403.936620048117180.342423463.936720289118186.232433524.736820533119192.282443586.336920780120198.482453648.837021030121204.852463712.137121286122211.382473776.237221539123218.092483841.237321803124224.962493907--